- Source: Helio Courier
The Helio Courier is a cantilever high-wing light STOL utility aircraft designed in 1949.
Around 500 of these aircraft were manufactured in Pittsburg, Kansas, from 1954 until 1974 by the Helio Aircraft Company. The design featured four leading edge slats that deployed automatically, and large trailing edge flaps. The engine was the 295 hp Lycoming GO-480, which had a gearbox that lowered the output RPM and allowed for the use of a large three-bladed propeller to further improve takeoff performance. Couriers were famous for their takeoffs, which often took only a few plane lengths and then climbed at very high angles. During airshow demonstrations, it was common for the aircraft to actually take off across a 100 - 200 foot wide runway.
During the early 1980s, new owners (Helio Aircraft Ltd.) made an attempt to build new aircraft with direct-drive Lycoming engines, to replace troublesome and expensive geared engines. In a further effort to reduce weight, a new composite landing gear was featured. The new models also featured modest winglets. Two models were produced, the H-800 and H-700. A total of 18 aircraft were built. The rights to the Helio Stallion and Helio Courier were acquired by Helio Aircraft of Prescott, Arizona.
Design and development
Professor Otto C. Koppen designed aircraft for the Stout Metal Airplane Division of the Ford Motor Company, including the Ford Flivver, an aircraft that was supposed to be mass-produced by Ford. Koppen went on to design the Helio Courier.
The demonstrator for the Courier's concept, "Helioplane #1", was converted by the then-local Wiggins Airways firm from a Piper PA-17 Vagabond Trainer, one of the so-named "short-wing Pipers" in production following World War II. Only the cabin area of the PA-17's original airframe remained unmodified, with the fuselage lengthened by four feet (1.2 meters), given a taller fin-rudder unit, clipped the Vagabond's stock 29 ft-3 inch (8.92 meter) wingspan down to only some 28.5 feet (8.7 meters), fitted the shortened wings with full-span leading-edge slats, long-span wing flaps that forced the ailerons to be much diminished in their span - only occupying the two outermost rib bays inboard of the wingtip; and a longer-travel main landing gear of a taller design, not unlike that of the 1930s-origin Fieseler Fi 156 Storch German military short take-off and landing (STOL) pioneer aircraft. The powerplant for the demonstrator was switched to the Continental C85 boxer-four cylinder air-cooled engine, upgraded with fuel-injection, and uniquely equipped with a multi-belt speed reduction unit to drive its Aeroproducts nine-foot (2.75 meter) diameter, variable-pitch two-blade propeller, which contributed greatly to the amazing STOL flight characteristics of the demonstrator aircraft. The demonstrator's first flight took place on April 8, 1949, flying from what was then called the Boston Metropolitan Airport.
For the construction of the production Courier aircraft, its all aluminum-clad airframe features a welded 15G steel-tube center section fuselage, with shoulder harnesses that protect the occupants in an emergency. The wings are of conventional aluminum construction, but feature Handley Page leading-edge slats that deploy automatically when the aircraft's airspeed falls below a certain value — 55 to 60 miles per hour (89 to 97 km/h). The slats contribute to the Helio's outstanding short takeoff and landing capability, and allow for stall/spin-proof controllable flight. In conjunction with the leading-edge slats, 74% of the trailing edge incorporates high-lift slotted flaps, which together with interrupter blades atop each wing when roll control is lost at very low airspeed, allows for a tight turning radius. The Helio Courier could maintain control at speeds as low as 27 miles per hour (43 km/h).
The design of the Helio features a large vertical tail surface and rudder for control at very low flight speeds. However, on conventional geared aircraft (taildraggers), the airplane tends to be sensitive to crosswinds, thus a crosswind gear option is available, allowing the main tires to caster left or right 20 degrees, increasing the crosswind component to 25 miles per hour (40 km/h). The Helio has its main gear placement far forward of the cabin, enabling hard braking on unprepared landing areas. A tricycle-gear model was produced, but is unsuitable for unprepared rough terrain.
Helios are also capable of being equipped with floats; both straight and amphibious floats being offered.
Operational history
With a minimum-control speed of around 28 mph, the Courier is perfectly suited for confined off-airport operations. The first one was certified in July 1954 and powered by the 260 hp Lycoming GO-435-C2B2. The first production Courier (Serial Number 001, dubbed "Ol' Number 1")C-G001 was previously owned and operated by JAARS as N242B until 2010. Jaars Helio Courier has been a frequent airshow performer at EAA AirVenture Oshkosh for decades, displaying its slow flight capability in front of thousands and serving as a drop plane for the Liberty Parachute Team.
In 1957, a "Strato Courier" set an altitude record over Mexico City, Mexico at 31,200 ft powered by a geared Lycoming GSO-480-A1A5 (340 hp), only one was built. The Super Courier, a more powerful derivative, was used by the U.S. Air Force from 1958 onward, by the U.S. Army Special Forces in the 1960s and 1970s and by Air America during the Vietnam War as the U-10. In U.S. Army and Air Force service, the U-10 Super Courier was used for liaison work, light cargo and supply drops, psychological warfare, forward air control (Air Force), insertion and extraction by land and sea (Army), and reconnaissance. Various versions were produced up through the 1980s, including turbine-powered variants.
The Super Courier saw military service in the United States as the U-10 (ex L-28). Over 120 were built: The L-28A (2, later redesignated U-10A), U-10A (26), U-10B extended range and paratrooper doors (57), and the U-10D with a higher gross weight(36). There was no U-10C.
Helios remain very popular among bush pilots in Canada (32 current) and Alaska and missionaries who fly into rough, relatively unprepared jungle airstrips because of its superior STOL abilities. Some operators use the Helio Couriers for aerial observation. Both Winged Vision Inc. of Gaithersburg, Maryland and the Pima County, Arizona, Sheriff's Department each operate two of the rare tri-gear model and mount gyro-stabilized cameras under the wing for aerial observation. Pima County mounts a FLIR camera for law enforcement, and Winged Vision mounts a high definition television camera for coverage of major sports events.
Variants
Koppen-Bollinger Helioplane
Original prototype soon re-named Helio Courier.
Helioplane Four
unknown possible variant.
Helioplane Two
unknown possible variant.
Hi-Vision Courier
unknown possible variant.
H-291
Prototype, one built.
H-295 Super Courier
Variant with a Lycoming GO-480-G1D6, purchased by USAF as U-10D, 173 built.
HT-295 Super Courier or Trigear Courier
H-295 with tricycle undercarriage, 19 built.
H-250 Courier
H-295 with lengthened fuselage and Lycoming O-540-A1A5 engine, 41 built.
H-391 Courier
Prototype with Lycoming GO-435-C2 engine, one built.
H-391B Courier
Production version of H-391, 102 built.
H-392 Strato Courier
High-altitude version of H-391 with Lycoming GSO-480-A1A5 engine (340 hp).
H-395 Super Courier
H-391B with Lycoming GO-480-G1D6, purchased by USAF as U-10A and U-10B, 138 built.
H-395A Courier
Variant of the H-395 with a Lycoming GO-435-C2B6 engine, seven built.
H-500 Twin Courier
Twin-engined H-395 for the CIA. Very little information available except seven delivered to the CIA under front designation U-5.
H-550 Stallion
Turboprop powered development
H-580 Twin Courier
A longer nosed H-500 with twin wing mounted piston engines, five built.
H-634 Twin Stallion
Planned twin Allison C250 powered Stallion.
H-700 Courier
H-295 with redesigned wing and undercarriage and Lycoming TIO-540-J2B engine.
H-800 Courier
H-700 with Lycoming IO-720-A1B engine, 18 built (H-700 and H-800 together).
L-24 Courier
Military version of the H-391 Courier.
L-28 Courier
Military version of the H-395 Courier.
U-5 Twin Courier
Probable front designation for CIA Twin Couriers.
U-10 Courier
Re-designation of L-28 Courier
Helio AU-24 Stallion
Military designation for H-550 Stallion
Operators
= Military operators
=Bophuthatswana
Bophuthatswana Air Force – 2 operated from 1982.
Guyana
Guyana Defence Force
Italy
Italian Air Force operated 1 Helio Courier aircraft from 1961 to 1982
Peru
Thailand
Royal Thai Air Force
United States
Civil Air Patrol
United States Air Force
4410th Combat Crew Training Squadron
United States Army
= Civil operators
=Air America
JAARS
North-Wright Airways
Wright Air Service
Aircraft on display
Thailand
7135 – Type 1 on display at the Royal Thai Air Force Museum in Bangkok. It has the USAF serial number 66-14332.
United States
Original "Helioplane No.1" demonstrator aircraft is in storage at the Paul Garber Facility of the National Air and Space Museum in Suitland, Maryland.
62-3606 – U-10A on static display at the Memorial Air Park at Hurlburt Field in Mary Esther, Florida.
63-13096 – U-10B on static display at the Museum of Aviation at Robins Air Force Base in Warner Robins, Georgia.
66-14360 – U-10D on static display at the National Museum of the United States Air Force at Wright-Patterson Air Force Base in Dayton, Ohio.
1216 – H-295 on static display at the Alaska Aviation Museum in Anchorage, Alaska. It was formerly owned by Lowell Thomas Jr.
Specifications (U-10D Super Courier)
General characteristics
Crew: 1
Capacity: 5 pax / 1,320 lb (599 kg) payload
Length: 30 ft 8 in (9.35 m)
Wingspan: 39 ft 0 in (11.89 m)
Height: 8 ft 10 in (2.69 m)
Airfoil: NACA 23012
Empty weight: 2,080 lb (943 kg)
Gross weight: 3,400 lb (1,542 kg)
Max takeoff weight: 3,400 lb (1,542 kg)
Fuel capacity: 120 gal
Powerplant: 1 × Lycoming GO-480-G1D6 6-cylinder air-cooled horizontally-opposed piston engine, 295 hp (220 kW) at 3400 rpm for take-off
285 hp (213 kW) at 3000 rpm, maximum continuous power
Propellers: 3-bladed Hartzell HC93Z20-1B/10151-C (or HC-B3Z20-1/10151-C), 8 ft 0 in (2.44 m) diameter constant-speed propeller
Performance
Maximum speed: 148 kn (170 mph, 274 km/h)
Cruise speed: 140 kn (160 mph, 260 km/h)
Never exceed speed: 164 kn (189 mph, 304 km/h)
Maximum structural cruising speed: 140 kn (161 mph; 259 km/h)
Maximum manoeuvring speed: 85 kn (98 mph; 157 km/h)
Maximum flaps extended speed: 65 kn (75 mph; 120 km/h)
Maximum rough air speed: 130 kn (150 mph; 241 km/h) flaps up
Maximum rough air speed: 80 kn (92 mph; 148 km/h) flaps down
Range: 950 nmi (1,090 mi, 1,760 km) with 120 US gal (100 imp gal; 450 L) fuel
Service ceiling: 20,500 ft (6,200 m)
g limits: +3.8 flaps up, +2 flaps extended
Rate of climb: 1,200 ft/min (6.1 m/s)
See also
Related development
Helio AU-24 Stallion
Helio Rat'ler
Helio Twin Courier
Aircraft of comparable role, configuration, and era
De Havilland Canada DHC-2 Beaver
Cessna 180
Cessna 185
Dornier Do 27
Maule M-5
Max Holste Broussard
Murphy Moose
Scottish Aviation Pioneer
Pilatus Porter
References
= Notes
== Bibliography
=Elliot, Bryn (March–April 1997). "Bears in the Air: The US Air Police Perspective". Air Enthusiast. No. 68. pp. 46–51. ISSN 0143-5450.
Ogden, Bob. Aviation Museums and Collections of North America. Tonbridge, Kent, UK: Air-Britain (Historians) Ltd, 2007. ISBN 0-85130-385-4.
Simpson, R. W. Airlife's General Aviation. Shrewsbury, UK: Airlife Publishing, 1995, pp. 208–210. ISBN 1-85310-577-5.
Taylor, Michael J. H. Jane's Encyclopedia of Aviation. London: Studio Editions, 1989. ISBN 0-517-69186-8.
World Aircraft Information Files. London: Bright Star Publishing, File 896, sheet 18.
External links
Helio Aircraft homepage
Smithsonian NASM page on Helioplane #1, awaiting restoration Archived 2016-12-28 at the Wayback Machine
NMUSAF Page on Helio Super Courier
"Rugged Light Plane Takes to the Air After 30-yard Run." Popular Mechanics, November 1954, p. 144.
A Low-Cost Air Transportation and Communication System for Remote Areas of the Philippines – Internet Archive
Kata Kunci Pencarian:
- Helio Courier
- Helio Twin Courier
- Helio AU-24 Stallion
- Helio Aircraft Company
- Helio
- Lycoming IO-720
- Lycoming O-480
- Courier (disambiguation)
- Air America (airline)
- Bush plane
